Study and improvement of aluminium doped ZnO thin films: Limits and advantages

作者：Aragones Albert C; Palacios Padros A; Caballero Briones F; Sanz Fausto^*

来源：Electrochimica Acta, 2013, 109: 117-124.

DOI：10.1016/j.electacta.2013.07.053

• AZO films
• Electrodeposition
• Burstein-Moss effect
• Photocurrent response
• Transparent conductive oxides
• Thin film solar cells

ZnO:Al films were deposited at 70 degrees C at a fixed -1.1 V potential onto ITO substrates from a 0.01 M Zn(NO3)(2)+x Al(NO3)(3)center dot 9H(2)O electrochemical bath, with Al3+ concentrations between 0 and 2 mM. Electrodeposition conditions were optimized to remove bubbles, increase grain size homogeneity and ensure adherence. Films were characterized by field emission scanning electron microscopy, X-ray diffraction, X-ray photoelectron spectroscopy, UV-vis transmittance, electrochemical impedance spectroscopy and photocurrent spectroscopy. Films were crystalline with the wurtzite structure and present a morphology made of hexagonal nano-pillars. It was found that Al incorporation increases gradually up to similar to 11 at% for samples prepared within the concentration range 0.0-0.3 mM Al3+ in the bath. For higher Al3+ contents (%26gt;0.4 mM) an amorphous Al2O3-like compound develops on top of the films. In the grown films with Al contents up to 11 at%, changes in the optical band gap from 2.88 eV to 3.45 eV and in the carrier densities from 10(19) to 10(20) cm(-3) were observed. The blue shift in the band gap energy was attributed to the Burstein-Moss effect. Changes in the photocurrent response and the electronic disorder were also discussed in the light of Al doping. Optical transmittances up to 60% at 550 nm were obtained, thus making these films suitable as transparent and conductive oxide films.

• 出版日期2013-10-30