Application of a CO2-stripping system for calcium removal to upgrade organic matter removal and sludge granulation in a leachate-fed EGSB bioreactor

作者：Lu, Xueqin; Chen, Shanping; Luo, Jinghuan; Qian, Guangren; Liu, Jianyong^*; Zhen, Guangyin; Li, Yu-You

来源：RSC Advances, 2016, 6(11): 9286-9296.

DOI：10.1039/c5ra26444h

• SEQUENCING BATCH REACTOR
• WASTE ACTIVATED-SLUDGE
• FE(II)-ACTIVATED PERSULFATE OXIDATION
• EXTRACELLULAR POLYMERIC SUBSTANCES
• PARALLEL FACTOR-ANALYSIS
• MUNICIPAL SOLID-WASTE
• BLANKET UASB REACTORS
• OIL MILL EFFLUENT
• LANDFILL LEACHATE
• FLUORESCENCE EXCITATION

The application of CO2-stripping system for calcium removal to upgrade organic matter removal and sludge granulation in a leachate-fed EGSB bioreactor was evaluated. Three-dimensional excitation-emission matrix (3D-EEM) spectroscopy combined with parallel factor (PARAFAC) analysis was used to characterize the transformation of the effluent dissolved organic matter (DOM) during the operation. Xray diffraction (XRD), Fourier-transform infrared (FT-IR) and scanning electronic microscopy (SEM) were used to assess the effects of a CO2-stripping unit on the microstructure of the granules. The introduction of the CO2-stripping system reduced the calcium concentration while upgrading methane evolution. The methane yield reached 0.33 L CH4 per g CODremoved in the bioreactor with the CO2-stripping unit compared with 0.31 L CH4 per g CODremoved without the unit as the control. The combined system produced 80% and 50-60% chemical oxygen demand (COD) and total nitrogen (TN) removal under steady-state conditions, which were 6.3% and 41.0% higher than those of the control, respectively. With 3D-EEM-PARAFAC analysis, three fluorescence components, associated as tryptophan protein-like (component 1, E-x/E-m = 275-280/355-365 nm) and humic-like substances (component 2, E-x/E-m = 240(295, 340)/450 nm and component 3, E-x/E-m = 320/320 nm), were identified from the effluent samples. The componential characterizations confirmed the favorable influence of the CO2-stripping unit on the transformation of DOM. Further analysis through XRD, FT-IR and SEM demonstrated that the use of the unit alleviated inactivation of the granules through removing calcium, which might be the core reason for the enhancement of the EGSB performance.

• 出版日期2016
• 单位上海大学