Mushrooms dehydration in a hybrid-solar dryer, using a phase change material

作者：Reyes Alejandro^*; Mahn Andrea; Vasquez Francisco

来源：Energy Conversion and Management, 2014, 83: 241-248.

DOI：10.1016/j.enconman.2014.03.077

• Mushrooms
• Hybrid solar dryer
• Phase change material (PCM)
• Effective diffusivity
• Drying kinetics
• Thermal efficiency

Mushrooms were dehydrated in a hybrid solar dryer provided with a solar panel of a total exposed surface of 10 m(2), electric resistances and paraffin wax as a phase change material. Mushrooms were cut in 8 mm or 12 mm slices. At the outlet of the drying chamber the air was recycled (70% or 80%) and the air temperature was adjusted to 60 degrees C. At the outlet of the solar panel the air temperature rose up to 30 degrees C above the ambient temperature, depending on solar radiation level.
The effective diffusivity, estimated by the Simplified Constant Diffusivity Model, considering or not shrinkage, fluctuated between 2.5 . 10(-10) m(2)/s and 8.4 . 10(-10) m(2)/s with R-2 higher than 0.99, agreeing with values reported in literature. The empirical Page's model resulted in a better adjustment, with R-2 above 0.998.
In all runs the dehydrated mushrooms showed a notorious darkening and shrinkage. Rehydration assays at 30 degrees C showed that in less than 30 min rehydrated mushrooms reached a moisture content of 1.91 (dry basis). Rehydrated mushrooms had a higher hardness compared with fresh mushrooms. The Simplified Constant Diffusivity Model and the Peleg's model adjusted to the rehydration data with RMSE values below 0.080.
Thermal efficiency fluctuated between 22% and 62%, while the efficiency of the accumulator panel varied between 10% and 21%. The accumulator allowed reducing the electric energy input.

• 出版日期2014-7