An innovative antisolvent precipitation process as a promising technique to prepare ultrafine rifampicin particles

作者：Vicosa Alessandra; Letourneau Jean Jacques; Espitalier Fabienne; Re Maria Ines^*

来源：Journal of Crystal Growth, 2012, 342(1): 80-87.

DOI：10.1016/j.jcrysgro.2011.09.012

• Antisolvent precipitation
• Bioavailability enhancement
• Drug nanoparticles
• Poorly water-soluble drug
• Rifampicin
• Room temperature ionic liquids

Many existing and new drugs fail to be fully utilized because of their limited bioavailability due to poor solubility in aqueous media (BCS drug classes 11 and IV). In this work, for accelerating dissolution of this kind of poorly water-soluble drugs, an antisolvent precipitation method that does not require the use of conventional volatile organic solvents is proposed. To demonstrate this technique, ultrafine particles of rifampicin were prepared using a room temperature ionic liquid (1-ethyl 3- methyl imidazolium methyl-phosphonate) as an alternative solvent and a phosphate buffer as an antisolvent. %26lt;br%26gt;Rifampicin solubility was measured in various solvents (1-ethyl 3-methyl imidazolium methylphosphonate, water and phosphate buffer), showing the RTIL good solvency for the model drug: rifampicin solubility was found to be higher than 90 mg/g in RTIL at 30 degrees C and lower than 1 mg/g in water at 25 degrees C. Additionally, it was demonstrated that introduction of rifampicin solution in 1-ethyl 3- methyl imidazolium methyl-phosphonate into the aqueous solution antisolvent can produce particles in the submicron range with or without hydroxypropyl methylcellulose as the stabilizer. The ultrafine particles (280-360 nm) are amorphous with enhanced solubility and faster dissolution rate. To our knowledge, this is the first published work examining the suitability of using RTILs for ultrafine drug nanoparticles preparation by an antisolvent precipitation process.

• 出版日期2012-3-1