Autonomous Microsystems for Downhole Applications: Design Challenges, Current State, and Initial Test Results

作者:Choi Myungjoon; Sui Yu; Lee In Hee; Meredith Ryan; Ma Yushu; Kim Gyouho; Blaauw David; Gianchandani Yogesh B; Li Tao*
来源:Sensors, 2017, 17(10): 2190.
DOI:10.3390/s17102190

摘要

This paper describes two platforms for autonomous sensing microsystems that are intended for deployment in chemically corrosive environments at elevated temperatures and pressures. Following the deployment period, the microsystems are retrieved, recharged, and interrogated wirelessly at close proximity. The first platform is the Michigan Micro Mote for High Temperature ((MHT)-H-3), a chip stack 2.9 x 1.1 x 1.5 mm(3) in size. It uses RF communications to support pre-deployment and post-retrieval functions, and it uses customized electronics to achieve ultralow power consumption, permitting the use of a chip-scale battery. The second platform is the Environmental Logging Microsystem (ELM). This system, which is 6.5 x 6.3 x 4.5 mm(3) in size, uses the smallest suitable off-the-shelf electronic and battery components that are compatible with assembly on a flexible printed circuit board. Data are stored in non-volatile memory, permitting retrieval even after total power loss. Pre-deployment and post-retrieval functions are supported by optical communication. Two types of encapsulation methods are used to withstand high pressure and corrosive environments: an epoxy filled volume is used for the (MHT)-H-3, and a hollow stainless-steel shell with a sapphire lid is used for both the (MHT)-H-3 and ELM. The encapsulated systems were successfully tested at temperature and pressure reaching 150 degrees C and 10,000 psi, in environments of concentrated brine, oil, and cement slurry. At elevated temperatures, the limited lifetimes of available batteries constrain the active deployment period to several hours.

  • 出版日期2017-10

全文