A membrane bioreactor for the simultaneous treatment of acetone, toluene, limonene and hexane at trace level concentrations

作者：Lebrero R; Volckaert D; Perez R; Munoz R; Van Langenhove H^*

来源：Water Research, 2013, 47(7): 2199-2212.

DOI：10.1016/j.watres.2013.01.041

• Membrane bioreactor
• Odorous VOCs
• Waste gas treatment
• Trace level concentrations

The performance of a flat-membrane biofilm reactor (MBR) for the removal of acetone, toluene, limonene and hexane at concentrations ranging from 1.3 to 3.2 mg m(-3) was investigated at different gas residence times (GRT): 60, 30, 15 and 7 s. A preliminary abiotic test was conducted to assess the mass transport of the selected volatile organic compounds (VOCs) through the membrane. A reduced transport of limonene and hexane was observed with water present over the dense side of the membrane. The presence of a biofilm attached on the dense side of the membrane following bioreactor inoculation significantly increased VOC transport. High acetone and toluene removals (%26gt;93%) were recorded in the MBR regardless of the GRT. To remediate the low hexane removal performance (RE %26lt; 24%) recorded at the initial stages of the process, a re-inoculation of the membrane with a hexane-degrading consortium embedded in silicon oil was performed. Although hexane removal did not exceed 27%, this re-inoculation increased limonene removals up to 90% at a GRT of 7 s. The absence of inhibition of hexane biodegradation by substrate competition confirmed that hexane removal in the MBR was indeed limited by the mass transfer through the membrane. Despite the low carbon source spectrum and load, the microbiological analysis of the communities present in the MBR showed high species richness (Shannon Wiener indices of 3.2-3.5) and a high pair-wise similarity (84 97%) between the suspended and the attached biomass.

• 出版日期2013-5-1