Nano-scale measurement of sub-micrometer MEMS in-plane dynamics using synchronized illumination

作者：Warnat S^*; Forbrigger C; Kujath M; Hubbard T

来源：Journal of Micromechanics and Microengineering, 2015, 25(9): 095004.

DOI：10.1088/0960-1317/25/9/095004

• MEMS
• illumination
• synchronized
• light
• strobe
• time constant

A method for measuring the sub-micrometer in-plane dynamics of MEMS devices with nano-scale precision using a CCD camera and synchronized pulsating illumination is presented. Typical MEMS actuators have fast responses (generally in the 1-200 kHz range), much faster than typical cameras which record a time averaged motion. Under constant illumination the average displacement is steady state and independent of dynamic amplitude or phase. Methods such as strobe illumination use short light pulses to freeze the motion. This paper develops the use of longer pulses of illumination that do not freeze the image, but make the average displacement depend on dynamic amplitude and phase; thus allowing both properties to be extracted. The expected signal is derived as a function of light pulse width and delay, and short versus longer pulses are compared. Measurements using a conventional microscope with replacement of the lamp with LEDs confirmed the derived equations. The system was used to measure sub-micrometer motion of MEMS actuators with similar to 5 nm precision. The time constant of a thermal actuator was measured and found to be 48 mu s. A resonant peak of a MEMS device was measured at 123.30 kHz with an amplitude of 238 nm.

• 出版日期2015-9