Analysis and Design of a Family of Two-Level PWM Plus Phase-Shift-Modulated DC-DC Converters

作者：Li, Shouxiang; Kang Xiangli^*; Smedley, Keyue Ma

来源：IEEE Transactions on Industrial Electronics, 2018, 65(6): 4650-4660.

DOI：10.1109/TIE.2017.2772177

• Isolated bidirectional dc-dc converter (IBDC)
• pulsewidth modulation plus phase-shift (PPS) control
• unified solution

A comprehensive analysis for a family of two-level pulsewidth modulation plus phase-shift (PPS)-modulated-isolated-bidirectional dc-dc converters is presented in this paper. Compared with the traditional phase-shift control, the PPS control features reduced current stresses, reduced conduction losses, guaranteed zero-voltage switching (ZVS) operation, and wide conversion-ratio variation range. In this paper, all eight operation modes are revealed, and then the unified solution of the power transmission capability for each mode is proposed, applicable for any two-level PPS converters. Based on the unified solution, component stresses and ZVS operation are analyzed to assist component selection. Most importantly, the control maps for three different combinations of the two-level PPS converters are proposed, to assist converter operation and design in the low-circulating-current region. In the control map, a circuit parameter k is proposed and its upper limit is found, providing a design limit to select switching frequency, leakage inductance, turns ratio, and power level. A 29-67 V/380 V prototype-the combination of group C plus group A-rated at 100-1000 W was built. The analysis is verified by both simulation and experimental results.

• 出版日期2018-6
• 单位西北工业大学