Anaerobic treatability of liquid residue from wet oxidation of sewage sludge

作者：Bertanza Giorgio^*; Galessi Raniero; Menoni Laura; Pedrazzani Roberta; Salvetti Roberta; Zanaboni Sabrina

来源：Environmental Science and Pollution Research, 2015, 22(10): 7317-7326.

DOI：10.1007/s11356-014-3303-z

• Anaerobic digestion
• COD removal
• Energy balance
• Liquid residue
• Sewage sludge
• Wet oxidation

Wet Oxidation (WO) of sewage sludge is a chemical oxidation of sludge at high temperatures and pressures by means of an oxygen-containing gas. The liquid stream originated by WO is easily biodegradable, and therefore, the recirculation to the biological Waste Water Treatment Plant (WWTP) may be a feasible solution. However, the WO effluent has a residual organic and nitrogen content so that its treatment may be required when the receiving WWTP has no surplus treatment capacity left. The aim of this research was the assessment of the anaerobic treatability of the WO liquid residue, in order to reduce the organic load to be recirculated to the WWTP, simultaneously promoting energy recovery. For this purpose, the liquid residue obtained during full scale WO tests on two different types of sludge was submitted to anaerobic digestion in a continuous flow pilot reactor (V = 5 L). Furthermore, batch tests were carried out in order to evaluate possible inhibition factors. Experimental results showed that, after the start-up/acclimation period (similar to 130 days), Chemical Oxygen Demand (COD) removal efficiency was stably around 60 % for about 120 days, despite the change in operating conditions. In the last phase of the experimental activity, COD removal reached 70 % under the following treatment conditions: Hydraulic Retention Time (HRT) = 20 days, Volumetric Organic Loading Rate (VOLR) = 0.868 kg COD/m(3)/day, Organic Loading Rate per Volatile Suspended Solids (OLRvss) = 0.078 kg COD/kg VSS/day, temperature (T) = 36.5 A degrees C, pH = 8. Energy balance calculation demonstrated anaerobic treatment sustainability.

• 出版日期2015-5