Pervaporation of aqueous dilute 1-butanol, 2-propanol, ethanol and acetone using a tubular silicalite membrane

作者：Sakaki Keiji^*; Habe Hiroshi; Negishi Hideyuki; Ikegami Toru

来源：Desalination and Water Treatment, 2011, 34(1-3): 290-294.

DOI：10.5004/dwt.2011.2855

• Pervaporation
• Silicalite membrane
• Separation factor
• Bio-butanol
• Permeate flux
• Silicone membrane

Pervaporation is a promising method to recover bio-alcohols from fermentation broths because of its high energy-saving potential. A silicalite membrane was prepared and applied to the pervaporation separation of 1-butanol, 2-propanol, ethanol and acetone from dilute aqueous solutions. In feed solvent concentrations in the range of 0.5-5.0 wt.%, the solvent flux of ethanol, 2-propanol and acetone increased with the increase of feed concentration, whereas 1-butanol flux was not greatly influenced by the feed concentration. In contrast to other solvents, the separation factor for 1-butanol solution decreased with the increase of feed 1-butanol concentration. This is because 1-butanol concentration in the permeate did not increase along with the increase of the feed 1-butanol concentration due to adsorption saturation. The solvent flux increased with the increase of separation temperature for all the solvents. The separation factor of 1-butanol and 2-propanol increased with the increase of separation temperature in the range of 30-60 degrees C, while the separation factor of acetone and ethanol was not greatly influenced by the separation temperature. Silicalite membrane shows higher selectivity toward 1-butanol solutions than silicone membrane when the feed concentration is low and the temperature is high.

• 出版日期2011-10