A self-powered active hydrogen sensor based on a high-performance triboelectric nanogenerator using a wrinkle-micropatterned PDMS film

作者：Uddin A S M Iftekhar; Chung Gwiy Sang^*

来源：RSC Advances, 2016, 6(67): 63030-63036.

DOI：10.1039/c6ra07179a

A triboelectric nanogenerator powered room-temperature hydrogen (H-2) sensor was fabricated using ZnO nanorod (NR) arrays decorated with Pd nanoparticles (NPs) and a wrinkle-micropatterned polydimethylsiloxane (PDMS) nanogenerator. A generated open-circuit voltage of 16.2 V and short-circuit current of 0.512 mu A were obtained when the device was exposed to a 5.3 N contact force at a fixed pressing frequency of 3 Hz. The instantaneous output power density from the device was 15.81 mu W cm(-2) when connected to a load resistor of 1 M Omega. The triboelectric output of the as-fabricated device was attributed to the enhanced triboelectrification of the wrinkle-micropatterned PDMS and the synergistic interplay of Pd/ZnO heterojunctions, which effectively acted as both the energy source and H-2 sensing signal. Upon exposure to 3 vol% H-2 at room temperature under the same applied force and deformation frequency, the triboelectric output voltage of the device decreased from 16.2 V (in dry air) to 1.04 V, through which a response value (sensitivity) up to 1457.69% was obtained. The device also showed an excellent low limit of detection (20 ppm), but a relatively slow response-recovery time (115126 s). These results suggest that the device can be used in practical applications and can stimulate new research for the development of next-generation portable self-powered active H-2 sensors.

• 出版日期2016